Service 4WD light on, trouble code C0388, C0374
General Motors has issued a Technical Service Bulleting #05-04-21-003C to address a problem with their 4WD vehicles where the Service 4WD message may appear or the 4WD light stays on. The TSB applies to the following vehicles.
2004–2007 Buick Rainier
2003–2006 Chevrolet Avalanche, Suburban, Tahoe
2003–2007 Chevrolet Silverado Classic, TrailBlazer, TrailBlazer EXT
2003–2006 GMC Yukon, Yukon XL
2003–2007 GMC Envoy, Envoy XL, Sierra Classic
2003–2004 Oldsmobile Bravada
2005–2007 Saab 9–7X with Four Wheel Drive or All-Wheel Drive
and Active All-Wheel Drive (RPO NP4) or Active Two-Speed (RPO NP8) Transfer Case
In addition to the message, you may notice erratic operation of the 4WD or AWD after driving through rain, snow, or a car wash. The cause may be a corrupted speed sensor signal. GM has discovered openings in the speed sensor wiring insulation that may short circuit the signal. This occurs most often on the rear speed sensor.
The fix is the fabricate a new harness or seal the existing harness. Or, for full-size pickup and full-size utility models, replace the pigtail harness that runs from the C151 connector under the hood to the transfer case with harness, 15832722 or 15224663, depending on vehicle equipment.
Another problem with the rear differential lock coil may also cause the message
To diagnose that, disconnect the rear differential lock harness from the rear differential lock coil connector.
Use a digital volt ohm meter (DVOM) and measure the resistance of the rear differential lock coil and pigtail from terminal to terminal.
The resistance should be 2.2-4.3 ohms and not shorted to ground
If your readings are out of spec, replace the rear differential lock coil. Unfortunately, the rear differential side bearing must be removed to replace the lock coil.
This problem shows up as a 4WD light stays on or Service 4WD
Got a car question? Click here and send it to me. I’ll do my best to get you an answer.
For more information on this repair or any others for your vehicle, buy an online subscription to either Alldatadiy.com or eautorepair.net. Click on this link to compare the two services: Compare Alldata and Eautorepair.
If you just need information for a single repair and want to save money,eautorepair offers a lower price 1-week subscription for only $11.99. Or, if you’ll be working on this vehicle in the future, you can buy a 1-year subscription (Alldatadiy.com for $26.99, or eautorepair.net $29.99)
© 2012 Rick MuscoplatPosted on by Rick Muscoplat