2010 Explorer Fuse Diagram: Exploring the Fuse Boxes
2010 Explorer Fuse Diagram: Find the correct fuse for the circuit
This 2010 Explorer Fuse Diagram shows two fuse boxes: the Battery Junction Box/Power Distribution Box located under the hood and the Smart Junction Box/Passenger Compartment Fuse Panel located under the dash.
To learn more about automotive fuses, see this article
To learn how to check a fuse visually or without removing it, see this article
2010 Explorer Fuse Diagram for Battery Junction Box/Power Distribution Box
The power distribution box is located in the engine compartment on the driver’s side. Find it near the firewall next to the master cylinder and wiper motor. The power distribution box contains high-current fuses that protect your vehicle’s main electrical systems from overloads.
How to find your fuse and the devices served by that fuse
There are 60 fuse/relay slots in the Battery Junction Box. The chart shows only 10 to speed up load time. Here’s how to find the fuse and circuit you want.
1) Change the number of entries showing (in the Show Entries Box) to 100 and scroll the list.
2) Enter the name of the component you’re searching for in the Search box.
3) Use the Next/Previous buttons at the bottom of the table
PJB= Passenger Junction Box
HEGO = Heated Exhaust Gas Oxygen Sensor
VMV= Vapor Mangement Valve
PTEC= Powertrain Electronic Control Module (PCM)
CMS= Central Security Module
BSM= Body Security Module
CHMSL= Center High Mounted Stop Light
| Fuse number | Amperage | Circuits protected |
|---|---|---|
| F1 | 50 | BATT 2 (Smart Junction Box) (passenger compartment fuse panel) |
| F2 | 50 | BATT 3 (Smart Junction Box) (passenger compartment fuse panel) |
| F3 | 50 | BATT 1 (Smart Junction Box) (passenger compartment fuse panel) |
| F4 | 30 | Fuel pump, Injectors |
| F5 | 30 | Third row seat (left) |
| F6 | 40 | ABS pump |
| F7 | 40 | Powertrain Control Module (PCM) |
| F8 | — | Not used |
| F9 | — | Not used |
| F10 | 30 | Power seat (right) |
| F11 | 30 | Starter |
| F12 | 30 | Third row seat (right) |
| F13 | 30 | Trailer tow battery charger |
| F14 | 30/40 | Memory seats (DSM)/Non-memory seats |
| F15 | 40 | Rear defrost, Heated mirrors |
| F16 | 40 | Front Blower motor |
| F17 | 30 | Trailer electronic brakes |
| F18 | 30 | Auxiliary blower motor |
| F19 | 30 | Running boards |
| F20 | 30 | Front wiper motor |
| F21 | 20 | Rear power point |
| F22 | 20 | Subwoofer |
| F23 | 20 | 4x4 |
| F24 | 10 | Powertrain Control Module (PCM) Keep Alive Power, Canister vent |
| F25 | 20 | Front power point/Cigar lighter |
| F26 | 20 | 4x4 module (4.6L engine only) |
| F27 | 20 | 6R Transmission module (4.6L engine only) |
| F28 | 20 | Heated seats |
| F29 | 20 | Headlamps (right) |
| F30 | 25 | Rear wiper |
| F31 | 15 | Fog lamps |
| F32 | 5 | Power mirrors |
| F33 | 30 | ABS valve |
| F34 | 20 | Headlamps (left) |
| F35 | 10 | AC clutch |
| F36 | 20 | Console bin power point |
| F37 | 30 | Driver window motor |
| F38 | 15 | 5R Transmission (4.0L engine only) |
| F39 | 15 | PCM power |
| F40 | 15 | Fan clutch, PCV valve, AC clutch relay |
| F41 | 15 | SDARS/DVD/ SYNC |
| F42 | 15 | Redundant brake switch, Electronic vapor management valve, Mass air flow sensor, Heated exhaust gas oxygen (HEGO) sensor, EVR, Variable cam timing (VCT)1 (4.6L engine only), VCT2 (4.6L engine only), CMCV (4.6L engine only), Catalyst monitor sensor |
| F43 | 15 | Coil on plug (4.6L engine only), Coil tower (4.0L engine only) |
| F44 | 15 | Injectors |
| F45A | — | Not used |
| F45B | — | Not used |
| F46A | — | Not used |
| F46B | — | Not used |
| F49 | Relay | Fuel pump relay |
| F50A | Relay | Fog lamps relay |
| F50B | Relay | AC clutch relay |
| F51 | — | Not used |
| F52 | — | Not used |
| F53 | — | One Touch Integrated Start (OTIS) (diode) |
| F54 | Relay | Trailer battery charger relay |
| F55A | Relay | PCM relay |
| F55B | Relay | Front wiper relay |
| F56A | Relay | Blower relay |
| F56B | Relay | Starter relay |
Explorer Fuse Diagram for Cabin/Passenger Compartment Fuse Panel
The cabin fuse panel is located on the far left-hand side of the instrument panel. Ford refers to this as the passenger compartment fuse box or the smart junction box (SJB).
| Fuse number | Amperage | Circuits protected |
|---|---|---|
| F1 | 20 | Moonroof, Adjustable pedals, DSM, Memory lumbar motor |
| F2 | 5 | Microcontroller power |
| F3 | 20 | Radio, Navigation amplifier, GPS module |
| F4 | 20 | OBD II connector |
| F5 | 5 | Moon roof, Door lock switch illumination, Auto dimming rear view mirror |
| F6 | 20 | Liftglass release motor, Door unlock/lock |
| F7 | 15 | Trailer stop/turn |
| F8 | 15 | Ignition switch power, PATS, Cluster |
| F9 | 2 | 6R Transmission control module/Powertrain control module (Ignition RUN/START), Fuel pump relay |
| F10 | 5 | Front wiper RUN/ACC relay in PDB |
| F11 | 5 | Radio start |
| F12 | 5 | Rear wiper motor RUN/ACC, Trailer battery charge relay in PDB, Radio |
| F13 | 15 | Heated mirror, Manual climate rear defrost indicator |
| F14 | 20 | Horn |
| F15 | 10 | Reverse lamps |
| F16 | 10 | Trailer reverse lamps |
| F17 | 10 | RCM (restraints), Passenger occupancy |
| F18 | 10 | Reverse park aid, Roll Stability Control™ (RSC) switch, RSC, 4x4 module, 4x4 switch, Heated seat switches, Auxiliary climate control |
| F19 | — | Not used |
| F20 | 10 | Climate control system, Brake shift |
| F21 | — | Not used |
| F22 | 15 | Brake switch, Bi-color stop lamps, High-mount brake lamp, All turn lamps |
| F23 | 15 | Interior lamps, Puddle lamps, Battery saver, Instrument illumination, Homelink |
| F24 | 10 | Cluster, Theft LED |
| F25 | 15 | Trailer park, Trailer electronic brake module |
| F26 | 15 | License plate/rear park lamp, Front park lamps, Manual climate |
| F27 | 15 | Tri-color stop lamps |
| F28 | 10 | Climate controls |
| Circuit Breaker 1 | 25A | Windows |
Auxiliary Relay Panel
Locate the Auxiliary Relay Panel in the cabin on either side of the Cabin Fuse Panel
Relay 1 Delayed ACC
©, 2018 Rick Muscoplat
Posted on by Rick Muscoplat